+39 045 8378 570   info@zuccatoenergia.it   8:30 - 12:30 /14:00-18:00 CEST

References ULH-Series Products

Veritas Logo

La Ceresina Cattle Farm

Manager: Azienda Agricola"La Ceresina" dei F.lli Baldisseri snc • Location: San Pietro in Gu (Padua, Veneto, Italy)
Plant: 1 x ZE-50-LT Low-Temperature Organic Rankine Cycle (ORC) Module, nominal output 50 kWe
Application: Heat recovery from engines (two MAN biogas-fueled gensets)

Mappa di San Pietro in Gu (PD)The cattle farm "La Ceresina", located in San Pietro in Gu, a small village in a corner of the province of Padua adjoining the province of Vicenza, is equipped with a biogas generation facility, and the biogas produced by the fermentation of the manure produced by their 1000+ head of cattle is used to fuel two MAN gensets.

The ORC system supplied by Zuccato Energia has the purpose to increase the efficiency of this small-scale thermoelectric power plant, born to take advantage of the favorable incentives for small-scale energy production from renewable sources.

This heat-recovery system - based on a ZE-50-ULH Organic Rankine Cycle module - produces an additional 50kWE by converting residual heat from the cooling jackets and the exhaust fumes of the above mentioned gensets into electricity, thus increasing overall plant output and efficiency.

The Zuccato Energia ORC module is in this case located outdoors, under a lean-to. Upon client request, the ORC control system has been customized, to allow its placement inside a nearby existing shelter (which also hosts the control boards for the engines and the fermentation plant) instead of being installed on board the skid as usual.

The cooling system used in this plant is peculiar, as it uses neither cooling towers nor dry coolers: cooling water - potable but very cold water taken from a local well - is just fed as drinking water to the cows after being brought to room temperature by passing through the heat exchangers of the ORC cooling stage, thus avoiding the gastrointestinal problems drinking too cold water can give them. The food-grade stainless steel walls of the exchanger give rise to no contamination.

The fuel used in this plant (biogas) is an environment-friendly, renewable power source, made cost-effective also by state ad regional incentives. It is also CO2-neutral, as the CO2 its combustion releases is the same that was captured by the plants upon which which the cattle fed

Below you will find a photogallery regarding this plant. Click on an image to enlarge it.

The firmThe firm The ZE-50-ULH skid being installed on locationThe ZE-50-ULH skid being installed on location Contact box and green "control room" containerContact box and green "control room" container The ZE-50-ULH ORC module skid seen from the frontThe ZE-50-ULH ORC module skid seen from the front The ZE-50-ULH ORC module seen from the sideThe ZE-50-ULH ORC module seen from the side The turbogeneratorThe turbogenerator The ORC module under its protective lean-toThe ORC module under its protective lean-to The complete installation (north side)The complete installation (north side) The complete installation (south side)The complete installation (south side)

Contents ©2019 Zuccato Energia Srl. All Rights Reserved.